1997 Ford Explorer/Mountaineer Transmission ASSEMBLY
download 1. Thoroughly clean the transmission case and extension housing in solvent and blow dry with compressed air. 2. Inspect the transmission case for the following: 1. Stripped bolt hole threads....
View Article2002 Ford Expedition Transfer Case 4R70W Transmission REMOVAL
download Removal 1. With the vehicle in NEUTRAL, raise and support the vehicle. 2. NOTE: Drain the transfer case if disassembly is required. Remove the drain plug and drain the transfer case. 3. Remove...
View Article1993 Mitsubishi Montero TRANSFER CASE DISASSEMBLY
download Disassembly (Ram-50) 1) Remove both 4WD indicator switches and steel balls. Remove speedometer gear assembly. Remove output shaft cover, gasket, wave spring and spacer. See Fig. 3. Remove rear...
View Article2004–2009 Toyota HighlanderTransmission Fluid or Gear Oil Seepage from...
download Some 2004 – 2009 model year Highlander, 2001 – 2005 model year RAV4, and 2004 – 2010 model year Sienna AWD (4WD) vehicles may display a transmission ?uid or gear oil seepage from a vent on the...
View Article2003 – 2004 Nissan MURANO AWD TRANSFER CASE NOISE WITH DAMAGED GEARS AND/OR...
download IF YOU CONFIRM: The AWD Transfer Case needs to be replaced because: • The case is cracked, and/or • Internal gears are damaged. NOTE: Damage, if it occurs, may have been caused by operating...
View Article1991 Chevy Truck Blazer Transfer Case: Service and Repair
download New Process 241 (Manual Shift Transfer Case) Transfer Case Replacement Fig. 19 Transfer Case Exploded View. New Process Models 231, 233 & 241 Transfer Cases Fig. 20 Oil Pump, Pickup Tube...
View Article1998 Chevrolet Pickup K3500 TRANSFER CASE DISASSEMBLY
download Exploded view of transfer case is not available. Note location of transfer case bolts and studs prior to disassembling transfer case. Bolts and studs MUST be installed in same locations as...
View Article2000 Chevy Truck S10/ T10 Blazer Transfer Case Replacement
download Removal Procedure 1. Raise the vehicle. Refer to Vehicle Lifting. 2. Remove the front propeller shaft. Refer to Propeller Shaft Replacement- Front. 3. Remove the rear propeller shaft. Refer to...
View Article2007 Dodge Nitro R/T TRANSFER CASE REMOVAL DISASSEMBLY
download 1. Raise vehicle. CAUTION: Do not allow propshafts to hang at attached end. Damage to joint can result. 2. 3. 4. 5. Remove the front and rear propeller shafts. Refer to REMOVAL . Support...
View Article1994 Ford Aerostar/ Ranger/ Explorer Electronic Shift Transfer Case Removal
download CAUTION: The three-way catalytic converter (5E212) is located beside the transfer case . Be careful when working around the three-way catalytic converter because of the extreme high...
View Article1991 Chevy G 20 Van Heater Core: Service and Repair Primary (Front) Heater Core
download Remove or Disconnect (Figures 5 through 10 and Figure 20) 1. Battery ground cable. 2. Coolant recovery tank. 3. Heater core hoses (140 and 141) (figures 6, 7, 8 and 20). ^ Place a clean pan...
View Article
